|
Section 1: PRODUCT INFORMATION
Name:
Ship-2-Shore-Industrial Thixotropic
Description:
Corrosion Inhibitor / Moisture Displacer / Lubricant / Dielectric (28.000
Volts)
Use:
Corrosion
Inhibitor / Penetrant / Lubricant / Ferrous and Non-ferrous metals and
dissimilar metals.
MSDS Number: 1002-SS
Appearance & Odour:
Red or Brown - with oily fragrance.
Emergency Telephone:
Local poison control
centre.
Product Information:
(250) 477-7325
Effective Date:
09/01/2006
Supersedes Date:
09/01/2005
UP TO PAGE INDEX
Section 2: COMPOSITION
Product is formulated
from highly refined hydrocarbon base stock, emulsifying and demulsifying
agents and hydrocarbon solvents and unique water displacing materials and
inhibitors.
UP TO PAGE INDEX
Section 3: HAZARDOUS INGREDIENTS
[Percentages OSHA PEL
CAS #]
Base Stock 5 mg/m3 (oil mist) 72623-85-9 & 72623-83-7
Hydrocarbon Solvent 2 to 4% (Stoddard - odorless kerosene) 100 ppm (vapour)
8008-20-6 & 8052-41-3
UP TO PAGE INDEX
Section 4: CHEMICAL CHARACTERISTICS
% Non-Volatiles (by
weight):
>85%
Boiling Point:
>212 degrees F.
Vapour Pressure:
(mm Hg. @ 25 deg. C) N/A
Vapour Density:
(Air = 1) Heavier than Air
Melting Point:
Not Applicable
Solubility in Water:
Insoluble
Evaporation Rate
(Butyl Acetate = 1): Slower than
Specific Gravity
(Water = 1):
0.908 (3 ml per 6 grams)
UP TO PAGE INDEX Section
5: EMERGENCY
& FIRST AID PROCEDURES
Skin:
Remove
excess by wiping and follow by washing with soap and water until there is
no odour.
Eyes:
Flush with
copious quantities of water (15 minutes). Lift Eyelids and flush inside.
Seek Physician if eyes become inflamed.
Inhalation:
Evacuate to fresh air. Apply CPR if required. If resuscitation is
required, assessment by a Physician is mandatory.
Ingestion:
DO NOT
INDUCE VOMITING! If vomiting occurs, take care to prevent aspiration..
Give 1/2 pint of milk to drink. Seek assessment of Physician.
Note to Physician:
Consult standard literature re: Hydrocarbon Poisoning.
UP TO PAGE INDEX
Section 6: HEALTH EFFECTS SUMMARY
Primary Route(s) of
Exposure:
Eyes-YES Skin-NO Inhalation-YES Ingestion-YES
Eye Contact:
Essentially non-irritating, however, vapors and/or mists can cause mild to
moderate irritation. Severity of reaction depends upon duration of
exposure and first aid procedures administered. Over exposure may cause
eyes to become red and/or watery
Skin Contact:
Essentially non-irritating. LD50 absorption for skin is 2000 mg/kg.
Prolonged or repeated Contact with the skin has not been a cause of
defatting or dermatitis in normal day to day handling of material. Effects
of over exposure may be dry, chapped skin.
Inhalation:
Non-toxic, *LC50 = 5000 ppm (rat, oral) [* Based on toxicity of
components]. Can cause irritation to nose and throat and upper respiratory
tract during prolonged exposure, but not normally. Exercise caution if
vapors are hot. If over-exposure occurs - may cause dizziness or headaches
or nausea.
Ingestion:
Virtually non-toxic, **LD50 1400 mg/kg (rat, inhalation) [** Based on
toxicity of Petroleum Distillate only]. May be harmful or fatal if
swallowed. Can cause severe irritation of mouth, throat and esophagus. Can
cause nausea, vomiting or gastrointestinal upset. May cause diarrhea.
Carcinogenicity,
Chronic Toxicity, Tetratogenicity, Mutagenicity, or Reproductive Toxicity:
Non-carcinogenic as listed by: ACGIH, IARC MONOGRAPHS, or OSHA (Based on
toxicity reports of component parts). No data available to indicate
product or components present at greater than 1% are chronic health
hazards or in concentrations of greater than 0.1% which may present
carcinogenic, mutogenic or genotoxic health hazards, or present in
concentrations greater the 0.1% that may cause birth defects or
reproductive toxicity.
UP TO PAGE INDEX
Section 7: REACTIVITY DATA
Product Stability:
Stable
Incompatibility:
Oxidizing Materials such as Liquid or Compressed Oxygen or Peroxides or
Chlorines
Hazardous
Decomposition:
Burning produces normal bi-products of combustion
including: Carbon Monoxide, Phenols, or Petroleum Products, Oxides of
carbon, nitrogen, sulfur, phosphorous, calcium, sodium, zinc, magnesium,
hydrogen sulfide, hydrogen chloride, aldehydes and other products of
incomplete combustion.
Hazardous Polymerization:
Will
NOT occur.
UP TO PAGE INDEX
Section 8: FIRE & EXPLOSION
HAZARDOUS INFORMATION
Flash Point:
>260 degrees F. (Method C0C)
Flammable Limits:
Not Applicable
Extinguishing Media:
C02, Dry Chemical, Foam, Water Spray.
Fire Fighting
Procedures:
Use full protective and self-contained breathing
apparatus. Cover with an extinguishing agent. Do NOT spray with water
using a direct stream directly into the burning liquid as this may spread
the fire. Use a water spray or mist to cool the fire.
Explosion Hazards:
Treat as a combustible liquid. Do NOT flame cut, drill or weld the empty
containers.
Fire Hazard
Identification:
NFPA STD. 704 Health - 0 Flammability - 1 Reactivity -
0 NFPA STD. 321 Combustible Liquid, Class III 3A
UP TO PAGE INDEX Section
9: SAFETY PRECAUTIONS
FOR SAFE HANDLING
Steps to be taken in
case of a spill:
Eliminate sources of ignition. Stop or reduce flow by
means of a dike or barricade. Absorb small spills using dry clay or a
commercial absorbent. Collect residue into suitable container for proper
disposal. Material may be washed into floor drains equipped with an oil
interceptor.
Waste disposal
method:
Dispose in an approved landfill site or incinerate at a
licensed waste reclaiming facility. Liquid waste may be removed by means
of a licensed reclaimer under used oil classification. Be sure to follow
all Local, State, & Federal Requirements.
UP TO PAGE INDEX Section
10: CONTROL MEASURES
Ventilation:
Provide sufficient ventilation by means of general or mechanical means to
ensure that exposure levels are kept below flammable limits.
Respiratory
Protection:
None normally needed unless atomizing in enclosed or
confined Use approved organic mist vapour respirator.
Eye Protection:
None normally required unless operator is using high pressure spraying
equipment and splashing may be likely to occur. Use approved face mask or
goggles.
Protective Gloves:
None needed
Protective Clothing:
None Needed
Personal Hygiene:
Wash face and hands with soap and water after use, especially before
eating or smoking or using the rest room facilities. Launder soiled
clothing and shoes / boots with detergent. Apply mild hand cream if hands
become dry or chapped.
UP TO PAGE INDEX Section
11: LABEL &
TRANSPORTATION INFORMATION
DOT Shipping Name:
Class B - Combustible Liquid
DOT Identification #:
Not restricted
UP TO PAGE INDEX
Section 12: REGULATORY INFORMATION
SARA TITLE III Information
Section 313 - Toxic
Chemicals:
This product does not contain any chemicals which are
listed as a carcinogen and in concentrations greater than 0.1 % of the
mixture pursuant to Section 313 of SARA
Section 302 -
EXTREMELY HAZARDOUS SUBSTANCES:
Pursuant to Section 302 of SARA TITLE
III, this product does not contain an extremely hazardous substance.
Material Information
System (WHMIS) Expiration Date:
Not Applicable
UP TO PAGE INDEX Section
13: USERS RESPONSIBILITY
A bulletin such as this
cannot be expected to cover all possible individual situations. As the
user has the responsibility to provide a safe workplace, all aspects of an
individual operation should be examined to determine if, or where,
precautions - in addition to those described herein - are required. Any
health hazard and safety information contained herein should be passed on
to your customers or employees, as the case may be.
UP TO PAGE INDEX Section
14: LIABILITY DISCLAIMER
The information
contained herein is, to the best of our knowledge and belief, accurate.
However, since the conditions of handling and use are beyond our control,
we make no guarantee of results and assume no liability for damage
incurred by use of this material. All chemicals may present unknown health
hazards and should be used with caution. Although certain hazards are
described herein, we cannot guarantee that these are the only hazards
which exist. Final determination of suitability of the chemical and
application of such products is the sole responsibility of the user. No
representations or warranties, either expressed or implied, of
merchantability, fitness for a particular purpose or any other nature are
made hereunder with respect to the information contained herein or the
chemical to which the information refers. It is the sole responsibility of
the user to comply with all applicable Federal, State and Local Laws and
Regulations. Any questions with regards to information contained herein
should be referred to the contact on the
website.
UP TO PAGE INDEX |
